Author |
Share Topic Topic Search Topic Options
|
krkees
Newbie
Joined: 05 Nov 2014
Online Status: Offline
Posts: 9
|
Topic: 179 Axle Issues Posted: 06 Nov 2014 at 10:47am |
Hey guys, just seeing this forum. So I have a 2013 RPOD 176. I noticed after no more than 2000 miles, that I had bad tread wear on the outside of the tire, opposite of slide out. My RV dealer took measurements provided by Dexter, and the wheel was forward about a .5 centimeter I think it was. They are testing it this week and will have more details to see if they are covering this under warranty. Needless to say, I was unable to take my camper LAST MINUTE to Colorado for the 6 weeks I was there. So I was furious, after putting on new tires for the trip and finding this. And no, I have never carried a full tank of water anywhere. I filled up and took it down the road one time, which was a 2-3 mile trip down the road at 30mph. Definitely no habit. The way it was bent or out of alignment, I would have to be hauling butt backwards and hit something to make it bend forward. I am positive it is 'defective' because I have never hit anything, never had it off road, etc. I was looking at selling it and getting the 179, and now I'm afraid to get one because of all the axel issues!
|
|
David and Danette
podders Helping podders - pHp
Joined: 24 Nov 2009
Online Status: Offline
Posts: 1215
|
Posted: 20 Oct 2014 at 4:10am |
The Vibes had the same 3,500 lb.axle as the r-pods and it was replaced with a 4,400 lb. axle for 2015. But the Vibe is 200 to 400 lbs. heavier than the r-pod 179. With the Vibes there was some problems with the 3,500 lb. axle in it not being able to properly handle the weight. I think if you are careful not to overload the 179 it would have no problems but it would be nice to have that extra margin of safety with a stronger axle. Perhaps in the future Forest River will replace the axle on the heavier r-pods with one stronger as they did with the 2015 Vibes.
|
2018 Vista Cruiser 19BFD (2018-
2012 Vibe 6503 (2014-2019)
2009 r-pod 171 (2009-2014)
Middle Tn
2014 Ram 1500 Quad cab
|
|
Old Dingo&Mrs.Dingo
Senior Member
Joined: 07 Jul 2012
Location: Tarentum, PA
Online Status: Offline
Posts: 138
|
Posted: 19 Oct 2014 at 11:57pm |
I have a "heavyweight" 'pod, I've never experienced any axle problems. When I pull it, it is always near Forest River's suggested maximum weight. I do check the lug nut torque and tire pressure before every trip.
|
Old Dingo and/or Mrs. Dingo
181G
2013 Jeep Grand Cherokee
|
|
kymooses
Senior Member
Joined: 01 Aug 2010
Location: Louisville, Ky
Online Status: Offline
Posts: 1807
|
Posted: 19 Oct 2014 at 7:36pm |
Originally posted by Budward
"Might" have experienced an issue?
|
The use of that word is not meant to diminish your issue or deny it, please don't think that at all. I only mean to say that while you personally may have experienced some issue with yours, it is not true of R-Pods in general, nor the 179.
|
|
|
wildfire305
Groupie
Joined: 22 Jul 2014
Location: Erlanger, KY
Online Status: Offline
Posts: 85
|
Posted: 19 Oct 2014 at 7:25pm |
I think all of the 2800+ pound pods toe the tires out at bottom. This gives the visual appearance that the axle is bent. It is at the capacity rating for the axle they use which doesn't leave much of a safety buffer, but isn't technically a problem. It will probably cause excessive tire wear, but I don't believe it is going to be recalled unless units start failing. I don't think we have any examples of an axle failure. Nearly all our camping is local, so I won't put enough miles on my tires to wear them out before they need to be replaced from age. This is probably what Forest River is betting on for most buyers also.
All should be more concerned about checking the lug nut torque before each trip and every 500 miles, we do have some examples of wheels falling off due to lack of proper torque. On our second trip, I got half a turn out of nearly all lugs. They were 100 pounds and tight from the dealer, so those aluminum wheels WILL loosen them.
|
2005 Dodge Durango 4.7 V8
OLD Tow Vehicle 2004 Honda Odyssey
2015 RP179 "73b"
OLD 2005 Viking Saga 2480ST popup
|
|
Budward
Senior Member
Joined: 21 Apr 2014
Location: SC/NC
Online Status: Offline
Posts: 438
|
Posted: 19 Oct 2014 at 4:29pm |
"Might" have experienced an issue?
|
2014 179
Towed by a 2015 Ford Transit Diesel
Supervised by a German/Aussie mix and a Labradoodle!
|
|
kymooses
Senior Member
Joined: 01 Aug 2010
Location: Louisville, Ky
Online Status: Offline
Posts: 1807
|
Posted: 19 Oct 2014 at 11:23am |
Originally posted by SandD
Anyone have axle issues with rpod178 or is it only the 179? |
It's not "an issue" with any Pod SanD. While this owner might have experienced an issue with theirs, it is not any type of known problem in the R-Pod travel trailers, on the 179's or any previous model.
|
|
|
SandD
Newbie
Joined: 09 Sep 2014
Location: nc
Online Status: Offline
Posts: 35
|
Posted: 18 Oct 2014 at 1:22pm |
Anyone have axle issues with rpod178 or is it only the 179?
|
|
rcamper
Newbie
Joined: 22 Sep 2014
Online Status: Offline
Posts: 16
|
Posted: 03 Oct 2014 at 7:51pm |
to much weight! 1 gallon of water equals 7.49 lbs
|
gone camping
|
|
Bill-GA
Senior Member
Joined: 13 Jan 2012
Location: Cumming, GA
Online Status: Offline
Posts: 214
|
Posted: 03 Oct 2014 at 10:11am |
Originally posted by Budward
New axle is in! .... Brakes are massive compared to old axle, that will be nice in mountains as they will heat up less, and they will wear less.
Dexter was a week late delivering the axle to the distributor and then they made it with the wrong mounting plates, I ordered high ....
|
I take it you ordered from Dexter with(?) brakes attached? New hubs? New bearings/racers on ordered axle? Was it more heavy duty ( supports more than 3500 #?)
What did you use as a reference? Axle part number? Called FR? Then went to Dexter site?
What was the approx. cost?
Sorry for all the Q's but never did an axle before. Many thanks, Bill from GA
|
Bill & Bev
13 yr old dachshund 'Elsa'
2010 RP-176T (tent & slide-out)
2011 Toyota Tundra 2WD TV
|
|